PDF download Download Article PDF download Download Article

This article describes how to adjust valve clearance on an air cooled VW Volkswagen) beetle. This must be done when the engine is cold.

Get Car Support Solve Any Problem

wH
Hi there! Do you have a question about how to diagnose or fix a problem with your car? I’ve read the manual so you don’t have to. Select your make, model, and year, then ask away!
*
*
  1. Determine valve clearance based on year: [1]
    • 1954 ~ 1960 (36HP) (Intake - .004") (Exhaust - .004")
    • 1961 ~ 1965 (40HP) (Intake - .008") (Exhaust - .012")
    • 1966 & Up (Intake - .006") (Exhaust - .006")
  2. [2]
    • 19mm / 21mm wrench
    • 13mm wrench
    • Medium sized flat bladed screwdriver.
    • feeler gauge (see above)
    • 2 new valve cover gaskets
    Advertisement
  3. Remove both valve covers by placing the screwdriver under the center of the valve cover bails (wire clips holding on the valve covers) and prying downward. If you have AC, you may need to slip a shop rag through the bail and give both ends a sharp snap downward to get the bail loose. [3]
    • The bail will move downward releasing the tension on the cover and you'll be able to work the cover off. Some oil will drip down at this point, don't worry, it will be a small amount.
    • Once it finishes dripping, use a rag to clean it off the heat exchangers.
    • The cap is held on by 2 clips, insert the screwdriver toward the top of the clip between the clip and the cap, gently pry outward and the clip will pop off the notches in the cap.
    • Don't remove the wires or the rotor inside the cap, just pull the cap up off the distributor and place it to the side suspended by the spark plug wires.
  4. Use the 19mm or 21mm wrench to turn the engine over by the generator / alternator pulley bolt (bolt holding the upper fan belt pulley on).
    • If the belt is loose, it may slip as you turn the bolt, when this happens, grab both sides of the belt as it enters and exits the upper pulley and squeeze them together with one hand.
    • Use the wrench to turn the pulley with the other, this will increase the tension enough to turn the engine over by this method.
  5. Do this by watching the distributor rotor. [4]
    • There is a small notch (oriented at about 4 o'clock) cut into the top edge of the distributor where the cap meets the metal distributor body. Rotate the engine until the rotor is pointing directly at the notch.
    • When it is lined up, look down at the crankshaft pulley (large pulley at the lower end of the fan belt). There will be a notch cut on the inside edge of the pulley that lines up with the split in the center of the engine case. It's a good idea to paint the notch with a small amount of visible paint (whiteout works for this but doesn't last). Line the notch up with the split, your engine is now at TDC for cylinder #1.
  6. [5]
    • Sometimes the gauge won't fit between the adjuster and the valve stem, in that case break the lock nut loose on the adjustment screw, loosen the screw one turn and insert the feeler gauge.
    • If it requires more than one turn to get the gauge inserted, double-check TDC.
  7. Once the gauge is inserted in to the gap, tighten the adjusting screw gradually while sliding the gauge back and forth until there is a noticeable “drag".
    • Do not over tighten the lock nut.
    • It should be tight, not overly tight.
  8. At the rear of the car using the 19mm or 21mm wrench, turn the engine counter-clockwise so the crankshaft (large) pulley turns 1/2 turn or 180 degrees. [6]
    • There will be another notch on the pulley exactly 180 degrees or halfway around from #1's TDC point.
    • Line the notch up with the split, your engine is now at TDC for cylinder #2.
  9. [7]
  10. Rotate the crankshaft another 1/2 turn counter-clockwise until the original notch is lined up with the split in the case, adjust cylinder #3.
  11. [8]
  12. [9]
  13. Replace the distributor cap, ensure the cap clicks into the locating notch in the distributor housing, and set the hold down clips. [10]
  14. 18
    [[Image:Adjust Valves on an Aircooled Volkswagon (VW) Beetle Step 18.jpg||center Remove any traces of the valve cover gasket from the head and valve covers.
    • Place the new gasket into a valve covers and place the cover on the head.
    • Lift up the bale till it clicks into the notch in the valve cover, A screwdriver may be required to get it the last of the way on.
  15. 19
    Clean the bottom of the engine, remove all oil residue and recheck the oil, add as necessary.
  16. If it is present, you may have mis-adjusted one of the valves.
  17. Advertisement

Community Q&A

Search
Add New Question
  • Question
    Why do some adjustments tell me to turn anticlockwise?
    Community Answer
    You will need some dish soap, and use the bubbles that come out of the valve covers to adjust the valves.
Ask a Question
      Advertisement

      Tips

      Submit a Tip
      All tip submissions are carefully reviewed before being published
      Thanks for submitting a tip for review!

      Warnings

      • The adjustment of each cylinder's valves must be done at top dead center for that cylinder. Failure to place the engine in a specific location will result in maladjusted valves and possible engine damage if it's run.
      • A correct one adjustment will last over several 10.000 mls : the only valves to correct the adjustment will be mostly the both of cyl. #3 due to higher thermic problems. Respecting this aspect an engine can run for several 100.000 mls without problems, regular oil changing incl.

      Check the compression regularly to know if the engine`s condition is well. Engines with a higher power than 40 HP (1300 cc) will not reach such a high mileage , as the thermic problem of cyl.# 3 is increasing with the performance of the engine. Highest mileages reach commonly the engines with 30 HP or 34 HP (1200 cc).

      Advertisement

      About This Article

      Thanks to all authors for creating a page that has been read 145,204 times.

      Reader Success Stories

      • Paul Welch

        Feb 27, 2017

        "Were it not for this article, I would've set my rocker arms to .028" intake and .032" exhaust, the ..." more
      Share your story

      Did this article help you?

      Advertisement