Download Article
Download Article
Owning a humidor is a great way to preserve the flavor of your cigars and prolong their life. Before you can begin using your humidor, you need to do some prep work. You will need to season the humidor and assure the humidity levels are adequate to safely store your cigars.
Steps
-
Gather your materials. You can get most materials you need at a local hardware store or department store. However, you also need a hygrometer. This is a device that measures moisture in the atmosphere. You may be able to find one at a drug, department, or hardware store. If you can't find one, buy one online. You will also need the following: [1] X Research source
- Distilled water or propylene glycol solution (50/50)
- A plastic bag
- A cloth or rag
- A sponge
-
Activate your hygrometer. This will make sure the hygrometer can adequately measure moisture. Take a towel and get it damp. Use only warm water.
- Wrap the hygrometer in the towel. Set it aside for 30 minutes.
- Remove the hygrometer in the towel and calibrate it so it reads 95 to 97%. Each hygrometer will be calibrated differently. Refer to your manufacturer's instructions to figure out how to calibrate yours.
- If your hygrometer already reads 95 to 97% when you remove it from the towel, it is ready to use. You do not need to calibrate it.
-
Do any necessary cleaning. If your humidor is new, make sure to gently wipe it down with a damp cloth using distilled water. This will allow you to remove all of the fine dust and wood shavings that may be there after its manufacturing. If you're preparing an older humidor, clean it out quickly before proceeding with the process. [2] X Research source
- If there is any old tobacco or debris in your humidor, spray the inside of the humidor with compressed air.
- Wipe down the interior of the humidor with a damp rag.
-
Submerge the humidifier in distilled water or fill it with the propylene glycol solution, as recommended by your humidor's manufacturer. Most humidors will come with a small, circular humidifier. If yours does not, you can order one online or buy one at a tobacco shop. Fill a bowl with distilled water. Place the humidifier in the bowl so it is completely submerged.
- Keep the humidifier face down. Leave it submerged for 2 to 3 minutes.
- Wipe off any excess water with a paper towel when you remove the humidor.
- Make sure you use distilled water. Tap water can damage a humidor.
-
Place a plastic bag and damp sponge in the humidor. Open your humidor. Line the bottom with a plastic bag. Get a sponge damp, using distilled water, and place the sponge on top of the plastic bag.
-
Install the hygrometer and humidifier. These are installed on the inside lid of your humidor. You should be able to figure out where to install by seeing where the pieces fit. If you're unsure, refer to your humidor's instructions manual.
- Once the hygrometer and humidifier are in place, close the humidor.
- Set the humidor aside somewhere where it will not be disturbed. Leave it closed for 12 to 24 hours.
-
Repeat the process again. After 12 to 24 hours have passed, you will repeat this whole process again. Submerge the humidifier in water and line the humidor with a plastic bag and a sponge. Then, install the humidifier and the hygrometer and set the humidor aside for 12 to 24 hours.
- Once you're done, the humidity level should be between 65% and 75%. It may be slightly higher right after you complete the process. Give the moisture levels a few minutes to go down.
- Your humidor may not be between 65% and 75% after repeating the process a second time. In this case, you'll need to repeat the process one more time.
-
Store cigars properly. You should remove the paper wrapping of a cigar before storing it in your humidor. Cigars that are stifled by wrapping will not breathe well. This will prevent them from being seasoned and flavored, which is the point of a humidor.
-
Limit how often you open your humidor. You want to keep humidity levels stable. Opening your humidor too often makes the inside lose moisture. Only open your humidor when you need to get a cigar. Take one out quickly and then close the humidor.
-
Remoisten as needed. A humidor's moisture level should be between 65 and 75%. Check the hygrometer once in a while to make sure that the level has not dropped.
- In the event the humidity has dropped, you will have to repeat the preparation process. You would remoisten the humidor the same way you initially prepared it. You may also want to check the seal of your humidor if the humidity is fluctuating too often, as it may not be a quality seal.
- Make sure to use distilled water when you repeat the process. This is just as important the second time around as it was the first. Tap water can harm the humidor and introduce contaminants into the closed system.
-
Store your humidor safely. A humidor should be stored in an area away from sunlight. You should also keep your humidor away from heat or air conditioning ducts, as well as interior lighting.
- A drawer is a good place to store a humidor.
- If you have children or animals, keep the humidor out of their reach.
Expert Q&A
Ask a Question
200 characters left
Include your email address to get a message when this question is answered.
Submit
Tips
- Periodically check the humidity level. Cigar experts generally accept 60-70% as a good range, but it is entirely up to you and how you like your cigars. Add distilled water (or a store-bought glycol solution) to your humidifier if it is too low.Thanks
- Some cigars can transfer flavor/aroma qualities to one another while in your humidor, so try to keep similar cigars grouped together.Thanks
Submit a Tip
All tip submissions are carefully reviewed before being published
Name
Please provide your name and last initial
Thanks for submitting a tip for review!
References
About This Article
Article Summary
X
To prepare a humidor, activate your hygrometer by wrapping it in a towel dampened with warm water for 30 minutes. Next, remove the towel and calibrate the hygrometer so it reads 95-97% humidity. Then, submerge the humidifier in distilled water for 2-3 minutes before lining the inside with a plastic bag and sponge. Finally, install the hygrometer and humidifier and repeat the entire process again 12-24 hours later until the humidity level reads between 65% and 75%. For tips on maintaining your humidor, read on!
Did this summary help you?
Thanks to all authors for creating a page that has been read 140,911 times.
Reader Success Stories
- "I've been smoking cigars for over 30 years, yet have still learned a few things. Thank you for posting this information." ..." more
93%
of readers found this article helpful
.
Click a star to add your vote
% of people told us that this article helped them.
"I've been smoking cigars for over 30 years, yet have still learned a few things. Thank you for posting this information."
..."
more
"Simple, easy to follow, good first time advice. Definitely worth a look."
"It was easy to follow!!! Really nappreciate the steps!!"
"I found this to be very good and easy to follow!"
"A really good guide for cigar newbies, thanks!"
